3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit header 2 mm type ab, 95, 110 and 125 signal contacts cp2 series 25 mm basic system unit 38, 44 and 50 mm module 2 mm grid spacing allows for high signal density at low cost eye of the needle compliant pin press-ft design reduces manufacturing time and cost three contact mating levels for early mate late break or hot swap applications reduces manufacturing time and cost feed through termination available for midplane applications additional grounding rows available for improved ground bounce and emi immunity mates with 5-row 3m ? metpak ? hshm, hm and cp2 sockets end-to-end stackable with 5-row 3m ? metpak ? hshm, hm and cp2 headers see regulatory information appendix (ria) for chemical compliance information date modifed: february 8, 2008 ts-2263-a sheet 1 of 7 ? ? ? ? ? ? ? ? ? ? physical insulation: material: glass filled polyester (pbt) flammability: ul94v-0 contact: material: copper alloy plating: see ordering information mechanical mating force: 0.75n/pin withdrawl force: 0.15n/pin mating and un-mating operations: 50 electrical contact resistance: 20 m insulation resistance: 10,000 m test voltage: 750 vac rms environmental temperature ratings: -40c to +85c pcb data recommended pcb plated through hole: 0.60.05 mm drill hole diameter: 0.70.02 mm hole platings: cu 25~50m, sn or snpb<10 m pcb thickness: 2.4-5.6 mm press-in force: 204n/pin on nominal hole diameter retention force: 13.5n/pin on nominal hole diameter
3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit header 2 mm type ab, 95, 110 and 125 signal contacts cp2 series ts-2263-a sheet 2 of 7 ordering information cp2-habxxx-xxx-xxxx recommended pcb layout signal contact quantity dimension a dimension b dimension c 95 38.00 [1.496] 38.30 [1.508] 36.00 [1.417] 110 44.00 [1.732] 44.30 [1.744] 42.00 [1.653] 125 50.00 [1.968] 50.30 [1.980] 48.00 [1.890] 5 2 1 " a " " c " z b c d e f a a c b t ai l m a t ing l eng t h l eng t h m a t i n g le n g t h l eng t h t a i l r t s z b c d e f a z b c d e f a z b c d e f a "b " number of signal contacts 095,110 and125 loading confgurations (see diagrams on following pages) grounding options: g= with ground pins blank= without ground pins emlb patterns primary tail length 1= 3.7 mm 4= 16.0 mm plating options tg30= 30 40 ? gold contact area 100 200 ? bright tin-lead 50 80 ? nickel underplate (ria e2 & c2 apply) fj= 10 20 ? gold contact area 200 300 ? matte tin 50 80 ? nickel underplate (ria e1 & c1 apply) kr= 30 40 ? gold contact area 200 300 ? matte tin 50 80 ? nickel underplate (ria e1 & c1 apply) gg30 = 30~40 u two gold contact areas 100~200 u bright tin-lead 50~80 u nickel underplate (ria c2 & e2 apply) ? this diagram serves only for part number descriptive defnitions. ? for standard product confguration please see following pages. please contact your local sales representative for customer specific product configurations. mm [inch] 0.13 1 0.3 tolerance unless noted 0. .0 .00 mm [ ] dimensions for reference only
3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit header 2 mm type ab, 95, 110 and 125 signal contacts cp2 series ts-2263-a sheet 3 of 7 cp2-hab095-e1-tg30 connector type b19 f e a a a a a a a a a a a a a a a a a a a d a a a a a a a a a a a a a a a a a a a c a a a a a a a a a a a a a a a a a a a b a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 cp2-hab095-ge1-tg30 connector type b19 f c c c c c c c c c c c c c c c c e a a a a a a a a a a a a a a a a a a a d a a a a a a a a a a a a a a a a a a a c a a a a a a a a a a a a a a a a a a a b a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a z c c c c c c c c c c c c c c c c 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 cp2-hab095-a1-tg30 connector type b19 f e b b b b b b b b b b b b b b b b b b b d b b b b b b b b b b b b b b b b b b b c b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b a b b b b b b b b b b b b b b b b b b b z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 cp2-hab095-ga1-tg30 connector type b19 f c c c c c c c c c c c c c c c c e b b b b b b b b b b b b b b b b b b b d b b b b b b b b b b b b b b b b b b b c b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b a b b b b b b b b b b b b b b b b b b b z c c c c c c c c c c c c c c c c 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit header 2 mm type ab, 95, 110 and 125 signal contacts cp2 series ts-2263-a sheet 4 of 7 cp2-hab095-ga4-gg30 connector type b19 f t t t t t t t t t t t t t t t t e r r r r r r r r r r r r r r r r r r r d r r r r r r r r r r r r r r r r r r r c r r r r r r r r r r r r r r r r r r r b r r r r r r r r r r r r r r r r r r r a r r r r r r r r r r r r r r r r r r r z t t t t t t t t t t t t t t t t 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 signal contact confguration worksheet connector type b19 f e d c b a z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 cp2-hab110-e1-tg30 connector type b22 f e a a a a a a a a a a a a a a a a a a a a a a d a a a a a a a a a a a a a a a a a a a a a a c a a a a a a a a a a a a a a a a a a a a a a b a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 cp2-hab110-ge1-tg30 connector type b22 f c c c c c c c c c c c c c c c c c c e a a a a a a a a a a a a a a a a a a a a a a d a a a a a a a a a a a a a a a a a a a a a a c a a a a a a a a a a a a a a a a a a a a a a b a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a z c c c c c c c c c c c c c c c c c c 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit header 2 mm type ab, 95, 110 and 125 signal contacts cp2 series ts-2263-a sheet 5 of 7 cp2-hab110-a1-tg30 connector type b22 f e b b b b b b b b b b b b b b b b b b b b b b d b b b b b b b b b b b b b b b b b b b b b b c b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b a b b b b b b b b b b b b b b b b b b b b b b z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 cp2-hab110-ga1-tg30 connector type b22 f c c c c c c c c c c c c c c c c c c e b b b b b b b b b b b b b b b b b b b b b b d b b b b b b b b b b b b b b b b b b b b b b c b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b a b b b b b b b b b b b b b b b b b b b b b b z c c c c c c c c c c c c c c c c c c 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 cp2-hab110-ga4-gg30 connector type b22 f t t t t t t t t t t t t t t t t t t e r r r r r r r r r r r r r r r r r r r r r r d r r r r r r r r r r r r r r r r r r r r r r c r r r r r r r r r r r r r r r r r r r r r r b r r r r r r r r r r r r r r r r r r r r r r a r r r r r r r r r r r r r r r r r r r r r r z t t t t t t t t t t t t t t t t t t 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 signal contact confguration worksheet connector type b22 f e d c b a z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit header 2 mm type ab, 95, 110 and 125 signal contacts cp2 series ts-2263-a sheet 6 of 7 cp2-hab125-e1-tg30 connector type b25 f e a a a a a a a a a a a a a a a a a a a a a a a a a d a a a a a a a a a a a a a a a a a a a a a a a a a c a a a a a a a a a a a a a a a a a a a a a a a a a b a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 cp2-hab125-ge1-tg30 connector type b25 f b b b b b b b b b b b b b b b b b b b b b b e a a a a a a a a a a a a a a a a a a a a a a a a a d a a a a a a a a a a a a a a a a a a a a a a a a a c a a a a a a a a a a a a a a a a a a a a a a a a a b a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a a z b b b b b b b b b b b b b b b b b b b b b b 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 cp2-hab125-a1-tg30 connector type b25 f e b b b b b b b b b b b b b b b b b b b b b b b b b d b b b b b b b b b b b b b b b b b b b b b b b b b c b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b a b b b b b b b b b b b b b b b b b b b b b b b b b z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 cp2-hab125-ga1-tg30 connector type b25 f c c c c c c c c c c c c c c c c c c c c c c e b b b b b b b b b b b b b b b b b b b b b b b b b d b b b b b b b b b b b b b b b b b b b b b b b b b c b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b b a b b b b b b b b b b b b b b b b b b b b b b b b b z c c c c c c c c c c c c c c c c c c c c c c 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
3 electronic solutions division interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? cp2 press-fit header 2 mm type ab, 95, 110 and 125 signal contacts cp2 series ts-2263-a sheet 7 of 7 cp2-hab125-ga4-gg30 connector type b25 f t t t t t t t t t t t t t t t t t t t t t t e r r r r r r r r r r r r r r r r r r r r r r r r r d r r r r r r r r r r r r r r r r r r r r r r r r r c r r r r r r r r r r r r r r r r r r r r r r r r r b r r r r r r r r r r r r r r r r r r r r r r r r r a r r r r r r r r r r r r r r r r r r r r r r r r r z t t t t t t t t t t t t t t t t t t t t t t 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 signal contact confguration worksheet connector type b25 f e d c b a z 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
regulatory information appendix 3m electronic solutions division/interconnect europe appendix e1: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product is rohs compliant 2005/95/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e2: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains lead in the compliant pin area in excess of the maximum concentration value allowed but is compliant by exemption under eu commission decision 2005/747/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e3: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment as amended by commission decision 2005/618/ec. this product contains lead in the solder tail area in excess of the maximum concentration value allowed . unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e4: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains decabde in the insulating material in excess of the maximum concentration value allowed but is compliant by exemption under eu commission decision 2005/717/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. ria-2217b-d
appendix e5: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical and electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains lead in excess of the maximum concentration value allowed but is compliant by exemption under item 6 of the annex to the directive. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. china appendix c1: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does not contain any of the following substances in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers; or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix c2: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers; or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. the numerical reference in the symbol above should not be construed as a representation regarding the products life or an extension of a product warranty. the product warranty is stated below. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the product warranty stated below. ria-2217b-d
important notice all statements, technical information, and recommendations related to 3ms products are based on information believed to be reliable, but the accuracy or completeness is not guaranteed. before using this product, you must evaluate it and determine if it is suitable for your intended application. you assume all risks and liability associated with such use. any statements related to the product which are not contained in 3ms current publications, or any contrary statements contained on your purchase order shall have no force or effect unless expressly agreed upon, in writing, by an authorized offcer of 3m. warranty; limited remedy; limited liability. this product will be free from defects in material and manufacture for a period of one (1) year from the time of purchase. 3m makes no other warranties including, but not limited to, any implied warranty of merchantability or fitness for a particular purpose. if this product is defective within the warranty period stated above, your exclusive remedy shall be, at 3ms option, to replace or repair the 3m product or refund the purchase price of the 3m product. except where prohibited by law, 3m will not be liable for any indirect, special, incidental or consequential loss or damage arising from this 3m product, regardless of the legal theory asserted. please recycle. printed in usa. ? 3m 2008. all rights reserved. ria-2217b-d 3 3m electronics solutions division 6801 river place blvd. austin, tx 78726-9000 u.s.a. 1-800-225-5373 www.3m.com/interconnects 3m is a trademark of 3m company. appendix c3: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers; or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. the numerical reference in the symbol above should not be construed as a representation regarding the products life or an extension of a product warranty. the product warranty is stated below. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the product warranty stated below.
|
